2024 Kia EV9

Beginning sometime after purchase, our 2024 Kia EV9 (VIN: [XXX]) developed a recurring failure of the multimedia display system (head unit). The screen goes completely dark after approximately 5 minutes of drive time and only restores after a full vehicle restart. This failure occurred approximately 10 to 14 times before we brought the vehicle in for service. Critically, when the multimedia screen goes dark, the rearview camera display is also rendered completely unavailable. As the rearview camera is federally mandated safety equipment under FMVSS 111, this failure left us unable to use the camera while backing up on multiple occasions, creating a serious safety hazard to pedestrians, cyclists, and other vehicles behind our car. The vehicle was dropped off at Grand Kia (Wheat Ridge, CO) on XXX for diagnosis. The service technician disassembled and reassembled the head unit and contacted Kia Techline for an action plan. We were told a replacement part was on order. As of the date of this complaint, the vehicle has been out of service for over six weeks with no confirmed repair timeline and minimal communication from the dealer or Kia America. This is our second significant warranty-related repair issue with this vehicle. We are filing this complaint to create a federal record of a safety defect involving the loss of federally mandated rearview camera functionality, and to request that NHTSA investigate whether this failure pattern exists across other 2024 Kia EV9 vehicles. Requested Action: Investigation of potential safety defect involving multimedia/head unit failure causing loss of rearview camera in 2024 Kia EV9 vehicles. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2024 Kia EV9. The contact stated that while attempting to release the rear seat belt to install a child safety seat, a significant amount of effort was required. The contact stated that after struggling with the seat belts over several months of use, the seat belt became fully jammed and no longer was able to be extended. The dealer was notified of the failure on several occasions. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 25,600.

When I started the car up, I noticed a little bit of chattering on the brake pedal, which seemed very unusual. I drove the car forward a little bit and then all of a sudden, all these lights displays and stop vehicle and check brake system now message showed up. The car was very sluggish to drive and had almost no brake pressure. I was able to drive it out of the parking lot (slowly and carefully). When I called a tow truck, I left the vehicle off for about 20 or 30 minutes, and then when I turned it back on, everything was fine no error messages and I had plenty of brake pressure. Post dealership update: They confirmed the issue and DTC code. Found that it was a ground wire that had a 3 ohm resistance (something about a “plastic coating” was mentioned in the paperwork!). They replaced the cable via SC360, and I’ve put about 800 miles on it since then with no issues.

For several weeks the car has felt out of balance and I had it in the shop once to be balanced. The balance felt it lasted a very short time. I took the car in today to be checked out and the passenger rear tire couldn’t hold a balance. Mechanic removed tire and the interior sound deadening foam had detached on greater than 50% of the diameter of the tire. This has been widely commented on as a common failure mode for these Hankook tires on EV9 vehicles. I wanted the remaining tires inspected but as they would hold a balance the dealer had no reason to put in the labor of removing and inspecting the foam. 285/45 R21

When making left turn or going over bumps, driver seat pops and feel shifted.

What component or system failed or malfunctioned, and is it available for inspection upon request? Two components failed simultaneously: (1) the rear passenger side tire experienced a catastrophic blowout while traveling at 65 MPH on the highway, and (2) the Tire Pressure Monitoring System (TPMS) failed to detect or warn of any tire pressure abnormality before or after the blowout. Following the blowout, the vehicle’s diagnostics screen displayed “All Systems OK” while the instrument cluster simultaneously showed a “Low Tire Pressure” warning — indicating a TPMS malfunction. The original blown tire has been retained and is available for inspection upon request. All four tires have since been replaced. How was your safety or the safety of others put at risk? A tire blowout at 65 MPH on a highway created an immediate risk, I briefly lost control of the vehicle as it became wobbly and unstable to steer, we were at at risk of collision, or rollover. Two minor children were passengers in the vehicle at the time. The simultaneous TPMS failure provided no advance warning, eliminating any opportunity to safely reduce speed or pull over before the blowout occurred. The vehicle had been in my possession for approximately two-three hours at the time of the incident. Has the problem been reproduced or confirmed by a dealer or independent service center? UNKNOWN Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? UNKNOWN Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No warning lamps, messages, or symptoms appeared prior to the tire blowout. The TPMS provided zero advance warning. After the blowout had already occurred and the vehicle was stopped on the roadside, the instrument cluster displayed a “Low Tire Pressure” warning. However, simultaneously, the Vehicle Diagnostics screen displayed “All Systems OK” with a green check-mark.

What component or system failed or malfunctioned, and is it available for inspection upon request? Tire Pressure Monitoring System (TPMS) failed to detect or warn of any tire pressure abnormality before or after the blowout. Following the blowout, the vehicle’s diagnostics screen displayed “All Systems OK” while the instrument cluster simultaneously showed a “Low Tire Pressure” warning. How was your safety or the safety of others put at risk? A tire blowout at 65 MPH on a highway created an immediate risk of loss of vehicle control, collision, or rollover. Two minor children were passengers in the vehicle at the time. The simultaneous TPMS failure provided no advance warning, eliminating any opportunity to safely reduce speed or pull over before the blowout occurred. The vehicle had been in my possession for approximately four hours at the time of the incident. Has the problem been reproduced or confirmed by a dealer or independent service center? UNKNOWN Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others?UNKNOWN Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? NO

We were driving in the middle lane, going straight approximately 25 MPH. The car lurched and almost flipped. We were able to pull over, the wheel was no longer spinning with the car and the tie rod snapped at a weld point. We could have been killed had we been going faster. My son was thankfully not in the car. I am desperately trying to get the car inspected but the dealership will not unless we pay. There were no warnings, but a whining sound began yesterday and we were on the way to the dealership this morning. Now there are warnings. There have been so many safety issues with this car. I will be filing 2 other reports for the seats.

In October 2025, my drivers seat began to move forward and fold on its own. I was sitting in the seat and crushed. I was able to free myself. I might have photos. I did call Kia. For a second time maybe a month ago, I was undoing my son's car seat from the latch and the seat began to fold up and pinned my neck and arm. I thought I was going to die. This was a rear passenger seat.

Purchased new all four tires (P 285 / 45 R 21 113V XL) in Dec, 2025 after confirming fits my vehicle. Warranty 60,000 miles. About 4 months later and about 1,800 miles of use, both rear tires have lost most of their tread and steel belts are showing per auto dealer. Front tires have also los quite a bit of tread. Vehicle had 4 wheel alignment before these tires were installed. Dealer & vehicle manufacturer representative confirmed no issue with vehicle. Also noted on 4/29/2026 that tire manufacturer web site states that these tires are no longer available for my vehicle. This is a significant safety hazard in its present state and worse yet subject to sudden tire failure.